Page 1 of 1
Verticle Glass Repair
Posted: November 7th, 2005, 3:27 pm
by Bois
There are previous threads regarding tips for repairing verticle glass but I ran up against one this weekend that I couldn't do. A gentleman approached me and said that he had an RV that had a rock chip at the bottom of the window with a 4-5" crack going up. I informed him that I could repair it. Now, I've done repairs on Hummers and Jeep Wranglers, and had done a repair on an RV the previous day. All had almost verticle glass. But this particular RV had VERTICLE glass - no slant at all (Winnebago Journey). My injector (Delta) was parallel to the ground. Since there was a crack above the chip, I couldn't mount the bridge above or below the chip and "play" with the adjusters. I asked the owner to lower the back chassis levelers and raise the front ones. This didn't improve the angle enough. I tried syringes with Delta's Premium and Magnabond resins. Each time I loaded the injector, resin would run out the mouth. I finally gave up and apologized.
Guess I need to find another type injector. Any comments???
Dale...
Re: Verticle Glass Repair
Posted: November 7th, 2005, 3:32 pm
by Delta Kits
Or you could call for tech support.
Or you could check out the current newsletter that discusses vertical repairs.
http://www.deltakits.com/newsletter/art ... 105-4.html
Re: Verticle Glass Repair
Posted: November 7th, 2005, 5:33 pm
by maxryde
You should be able to repair as if it were a little sloped using a syringe and then just be patient. Don
Re: Verticle Glass Repair
Posted: November 7th, 2005, 5:43 pm
by Delta Kits
maxryde wrote:Except of coarse when it comes from Matt or Jeff and they are ALLWAYS right!!!
Jeff is always right. Matt is only right when he agrees with Jeff.

Re: Verticle Glass Repair
Posted: November 7th, 2005, 6:23 pm
by DaveC
Delta Kits wrote:Jeff is always right.
Hmm ... methinks that spouse O' Jeff would have the final say on this issue:)
Re: Verticle Glass Repair
Posted: November 7th, 2005, 6:25 pm
by Thomas
HAHAHAHA...I take it Matt wont read this thread! LOL. But seriously, I hope to learn verticle repairs also when i have more experience. Thanks for the info on how to do it.
Re: Verticle Glass Repair
Posted: November 7th, 2005, 7:02 pm
by Delta Kits
He might read it, but he probably doesn't know how to post!

And Dave, you're right...SHE definitely won't read it, or I uh...would have phrased it differently!

Re: Verticle Glass Repair
Posted: November 7th, 2005, 9:06 pm
by dingmedic
I have 3 motorhome dealers, I have never had a problem. I dont use Delta but have another wsr in town that does, he has never had a problem. Did you adjust your bridge?????